vitality 50 2t 4t 1 Manuel atelier : Page 242

          16. ELECTRICAL EQUIPMENT                                                        VITALITY 50

 SERVICE INFORMATION
 GENERAL INSTRUCTIONS
 · It is not necessary to check the battery electrolyte or fill with distilled water.
 · Remove the battery from the motorcycle for charging. Do not remove the electrolyte cap..
 · Do not quick charge the battery. Quick charging should only be done in an emergency..
 · Charge the battery according to the charging current and time specified on the battery.
 · When charging, check the voltage (open voltage) with an electric tester.
 · When replacing the battery, do not use a traditional battery.


 SPECIFICATIONS                                          2-Stroke                   4-Stroke
                                Capacity                 12V3AH                     12V4AH
                                Voltage                13.013.2V                  13.013.2V
         Battery
                           Charging   Standard        0.4A/5H~10H                0.5A/5H~10H
                           current     Quick             4A/0.5H                    4A/0.5H
       Spark plug                  (NGK)                 BR8HSA                     C7HSA
                   Spark plug gap                      0.60.7mm                   0.60.7mm
                          Primary coil                0.1530.187                     0.5
                          Secondary coil
 Ignition coil resistance (with plug cap)            6.99k10.21K                     8.12K
                          Secondary coil
                          (without plug cap)         3.24k3.96K                       3K
           Pulser coil resistance (20)                80160             118.1118.2
                   Ignition timing               13.5°2°BTDC/3000rpm 28°2°BTDC/4000rpm


 TROUBLESHOOTING
 CHARGING SYSTEM
 No power                                        Intermittent power
 · Dead battery                                  · Loose battery cable connection
 · Disconnected battery cable                    · Loose charging system connection
 · Fuse burned out                               · Loose connection or short circuit in ignition system
 · Faulty ignition switch                        · Loose connection or short circuit in lighting system

 Low power                                       Charging system failure
 · Weak battery                                  · Loose, broken or shorted wire or connector
 · Loose battery connection                      · Faulty regulator/rectifier
 · Charging system failure                       · Faulty A.C. generator
 · Faulty regulator/rectifier



16-1